冬季裝載機保養小tips!

裝載機冬季保養指南

Wheel Loader

北方氣溫驟降，

對于裝載機用戶來講，

如何更好地保障機械設備良好運行，

無疑是一種考驗，

今天給大家總結了4點冬季養車的注意事項，

可以更好地助力設備安全過冬。

The sudden drop in northern temperatures poses a challenge for loader users. Ensuring the optimal operation of mechanical equipment in such conditions is undoubtedly a test. Today, we have summarized the following four points of winter maintenance considerations for everyone, which can better support the safe winter operation of the equipment.

01 燃油油路維護

Fuel System Maintenance

柴油選用：需根據當下的環境溫度，不同標號的柴油凝固點不同，選用柴油的標號如果高于以下溫度，發動機的燃油系統可能會結蠟，堵塞油路，影響發動機的正常工作。

Diesel Selection: Depending on the current environmental temperature, diesel with different cetane ratings has different cloud points. If the chosen cetane rating of diesel is higher than the following temperature, the engine's fuel system may experience waxing, leading to clogged fuel lines and affecting the normal operation of the engine.

燃油油路維護：清洗柴油箱，將油箱底部的沉淀物清除干凈。校驗工作情況不良的噴油油泵，確保正常工作。

Fuel System Maintenance: Clean the diesel tank by removing sediment at the bottom. Inspect and address any issues with the fuel injection pump to ensure proper functioning.

02 設備三漏檢測

Equipment Three Leaks Detection

在氣溫持續低于0℃，甚至更低時，設備會出現漏油、漏氣、漏水現象，所以在正式進入冬季之前一定要對整機的三漏情況進行全面檢修，排除隱患和故障。

When the temperature persists below 0℃, or even lower, equipment may experience oil, air, or water leaks. Therefore, before officially entering winter, it is essential to comprehensively inspect the entire machine for leaks, addressing potential risks and faults.

03 排凈儲氣罐內積水

Drain the accumulated water from the air reservoir.

冬季在每天工作完成之后，需要排放干凈儲氣罐內的積水，防止水分進入剎車氣路結冰堵塞，導致沒有剎車，最終引起安全事故。

In winter, after completing daily work, it is necessary to discharge the accumulated water inside the air reservoir to prevent moisture from entering the brake air system, causing ice blockages and resulting in brake failure, ultimately leading to safety accidents.

排放干凈油水分離杯內水分，防止水分進入油路結冰堵塞，引起整機起動困難或者是無法起動。

Clean the water in the oil-water separation cup to prevent moisture from entering the oil system, causing ice blockages and leading to difficulties in starting the entire machine or preventing it from starting.

04 低溫負荷作業

Low-Temperature Load Operation

在車輛起動，柴油機著火后，很多司機就想讓設備立即投入負荷作業，但由于室外溫度低，機油粘度大，這種情況很容易引起設備嚴重磨損。

After starting the vehicle and igniting the diesel engine, many drivers may want to put the equipment into operation immediately. However, due to the low outdoor temperature and high viscosity of the engine oil, this situation can easily lead to severe wear and tear on the equipment.

所以建議車輛啟動著火后，先在原地低速運轉5—10分鐘，期間可繞車檢查設備，避免不必要的損壞，然后再投入負荷作業。

Therefore, it is recommended that after the vehicle starts and the engine ignites, run at low speed in place for 5-10 minutes. During this time, inspect the equipment around the vehicle to avoid unnecessary damage before engaging in full-load operations.

- END -

山東恒旺集團以“讓最廣泛的用戶享受最高性價比的產品及服務”為使命，不斷推出新產品，提供全方位服務。主營產品類目齊全，包括挖掘機、推土機、鉆機、打樁機、壓路機、履帶運輸車等20大系列180余種。產品通過ISO、歐盟CE、德國TUV、法國BV等十余項安全檢測認證。

Shandong Hengwang Group, with the mission of "providing the widest range of users with the highest cost-effective products and services," continuously introduces new products and offers comprehensive services. Our main product categories are comprehensive, including excavators, bulldozers, drilling rigs, piling machines, road rollers, tracked transport vehicles, and more, totaling over 20 series and 180 varieties. Our products have obtained more than ten safety testing certifications, including ISO, EU CE, Germany TUV, France BV, and others.

干工程、選恒旺、事業興旺！

免費熱線：400-9975-666

歡迎您的致電~

For quality construction, choose Hengwang and prosper your career!

Toll-free hotline: 400-9975-666

聲明：本文系轉載自互聯網，請讀者僅作參考，并自行核實相關內容。若對該稿件內容有任何疑問或質疑，請立即與鐵甲網聯系，本網將迅速給您回應并做處理，再次感謝您的閱讀與關注。